EarthCore 36 Bedienungshandbuch

ISOKERN B-VENT FIREPLACEA PRODUCT OF EARTHCORE INDUSTRIES, LLC.INSTALLATION, OPERATION, MAINTENANCE andOWNER’S MANUALISOKERN MODELS IBV-36 and IBV-46I

10Combustible Floor System LoadingImportant: Floor framing for IBV installation will need tobe designed and built to accept substantial dead loads spr

11IBV Rough Framing DimensionsRough Framing DimensionsModel A B CIBV 36 43” 72”,83”,93” 26 3/4”IBV 46 53” 72”,83”,93” 26 3/

12IBV Assembly InstructionsGeneral Assembly Instructions: Earthcore Mortar (a thin-set type masonry adhesive) is used to glue all IBV masonry compone

Raised hearthfor wood orconcrete installsFlush Hearthon ConcreteFoundations OnlyEarthcoreMortar13IBV Assembly Instructions (cont.)Assembly Steps for I

Drill HoleEarthcoreMortarEarthcore MortarFirst CourseBack WallTop CourseBack WallEarthcore MortarHigh TemperatureWire ( 2 pc. / 12’ long)High Temperat

15IBV Assembly Instructions (cont.)Step 5: Once all the rebox wall components are set check the top surface of the rebox for level.Step 6: Begin the

FirebricksideGas or electriclineNOTE: Fill any gaps aroundline with Earthcore MortarFlex duct to fireplacefirebox (all parts non-combustible)Exterior wa

17IBV Assembly Instructions (cont.)Fire Brick Installation:The manufacturer requires that the replace reboxes be lined with a minimum one and one-ei

High TemperatureLimit Switch2 High TemperatureWiresTab to be bent upwardto stand vertical(both sides)18IBV Assembly Instructions (cont.)Metal Canopy I

19Venting InstallationAnchor Plate/ Damper Installation: Cut a twelve inch (12”) diameter hole in the center of the ceramic ber blanket which is the

Table of Contents2General Information ...

20Venting Installation (cont.)The IBV, per ANSI-Z21.50 standard, requires double wall, gas only B-Vent metal piping for the purpose of venting the app

21Venting Installation (cont.)Mechanical Vent Systems:It is acceptable to use mechanical draft systems, if the venting companies do the engineering ca

22Flush Wall Finish DetailIBVs are designed to be installed so that the rough front face of the Isokern rebox and smoke dome sit ush to the room fac

8“ min. Finished Opening8“ min.Wood (Flammable)Sheathing8” min8” min 8” minFront ofFirebox reference23Combustible wood sheathing such as plywood and p

24Flush Wall Fire Brick Finish DetailRecommended Fire Brick Detail: With drywall crossing over the face of the IBV smoke dome assembly (as previously

25Important: Since there is no re brick set along the top of the IBV rebox opening, when setting the noncombustible facing material (code required a

26Interior Full Masonry Veneer Finished Fireplace FrontsIsokern unit width dimensionExtent of Steel L4” Bearing3 ½” minimumclearanceSteel LWood (Flamm

Masonry VeneerWood (flammable)Sheathing4” 2” min.Min. clearanceMin. clearance8” min.Steel L27Interior Full Masonry Veneer Finished Fireplace Front Deta

CombustibleFloor System(non-flammable)CombustibleFloor System(non-flammable)Ceiling42”minimum clearancefrom openingto ceilingHearthExtension(non-combust

29ISO-FLAMES Gas Log Burner InstallationThe gas control valve is installed on the right side of the ISOFLAMES gas log burner. If the gas supply line c

3General Information IBV Models IBV-36 and IBV-46 are tested and listed by PFS Corp., USA Report No. 09-79 to ANSI Z21.50b-2009b-2009 and Canadian St

30ISOFLAMES® Gas Log SystemOWNER’S MANUALInstallation & Operating InstructionsISOFLAMES Gas Log Systems24” - 30”THE ISOFLAMES GAS LOG SYSTEM MUST

31General InformationTools Required:1. Adjustable wrench2. 3/8” aring tool3. Open-end wrench (7/16”)4. Open-end wrench (3/4”)5. Pipe thread sealer (N

32Safety Instructions Prior To Installation/Pilot Assembly Wire DiagramISOFLAMES FIREPLACE WIDTH FIREPLACE HEIGHT BTU NATURAL GAS BTU LIQUID BU

33Isoames Gas Log Burner InstallationIsokern Gas Burner Installation InstructionsFig. 1 - Burner System Detail - Bottom View1. MAKE SURE THE FIREPL

34Isokern Gas Burner Installation InstructionsFig. 4 - Connect gas supply7. LEAK TEST: Tu rn on the fi replace gas supply, and test at all co

35ISOFLAMES Gas Log Assembly InstructionsImportant: Although there is some fl exibility with the log placement, adequate spacing between the logs i

36Fig. 2-21Fig. 2-3Fig. 2-1Note: Highlighting added to improve clarity.12846357LOG PLACEMENTEach log in this gas log set is numbered here to assist i

FOR YOUR SAFETY READ BEFORE LIGHTINGWARNING: If you do not follow these Instructions exactly, a re or explosion may result causing property damage,

38Lighting Instructions (cont.)Important: The ISOFLAMES Series gas log system must be installed by a liscensed plumber or gas tter per code.WARNING:

39Maintenance:The ISOFLAMES gas log system will last a lifetime, but periodic maintenance (at least once a year) is recommended. Can you clean it your

4Safety InformationWARNING: This product contains or generates chemicals known to the state of California to cause cancer or birth defects or other r

40ISOFLAMES Customer Service & WarrantyCustomer ServiceEarthcore Industries, LLC is committed to customer service and exceeding customer expectati

41Warranty CardPlease cut along dashed lines and send to:Earthcore Industries, LLC6899 Phillips Industrial Blvd.Jacksonville, Fl 32256Attn: Technical

1REV 1 - 0909221329OPTIONAL ISOFLAME WALL SWITCH INSTRUCTIONSFig. 1 - Connect wall switch to remote receiver boxInstallation1. Install the wall switc

43Notes

Warranty & DisclaimerIsokern Fireplace Earthcore offers a lifetime warranty for all Isokern components, to be free from defects in materials that

5Safety Information17. Wherever insulation is used, the replace must not be placed directly against it. Keep all insulation and vapor barrie

6Assembled Firebox & Smoke Dome DimensionsEarthcore Industries, LLC. reserves the right to make changes at any time, without notice, in design, ma

7Component List & DimensionsPartNo.:2123FireplaceSize:36” W46” WQuantity:11PartNo.:12FireplaceSize:36” WQuantity:2PartNo.:1111FireplaceSize:36” W4

8Required Component ListIn addition to the standard IBV modular masonry rebox and smoke dome assembly components the IBV requires particular componen

9Required Clearance to CombustiblesImportant: “Combustibles” are dened as “normal construction materials” and considered to be: wood framing material